Back to all

Wired! (Battery Cable Service)

June 5, 2022

Colder weather brings out the worst in a vehicle's battery.  On a very cold day, you may have experienced that your engine cranks slowly when starting.  But while it may be the battery itself, it may also be the parts that transfer the power to other the other electrical components, the battery cables.  After all, you have to have some way to get the current out of the battery and out to where it needs to go.

Battery cables have a couple of enemies: corrosion and age.  You may have looked under the hood and noticed a light-colored powder or crust around the terminals.  That's what happens when acids corrode the ends of the battery terminals.  Corrosion inhibits the connection and may reduce the amount of power getting to the electrical accessories to the point where they are not working correctly, if at all.

Here are some symptoms of problems with your battery cables. You might notice a clicking sound when you turn the key, some of your vehicle's electrical parts (like the sound system or the horn) don't work or, in some cases, the vehicle won't start at all.

When you take your vehicle to a repair facility, the technician will use instruments to check voltages to see how much current is getting to what location. That includes a starter draw test during which the battery's voltage is checked when the starter is cranked.  The technician will also visually inspect the cables and the charging system. To make sure the alternator is putting out the right voltage, the technician will measure that as well. 

If the problem is found to be the battery cable assembly, the entire set may have to be replaced. Sometimes they can be repaired. 

During the colder months, it's vital that your vehicle has the proper power going to its electrical components.  Having a vehicle that won't start or run smoothly is not something you want to battle with when you're already up against challenging weather.  Keep your electrons flowing… and your vehicle moving.


Tuffy Tire & Auto Service Center Appleton
2940 E. College Ave.
Appleton, Wisconsin 54915
920-954-8500

More articles from Tuffy Appleton

Not Too Hot and Not Too Cold (Temperature Gauge)

May 12, 2024

You know your body temperature is supposed to be 98.6 degrees F, 37 degrees C. Your vehicle has a normal temperature, too, and if you pay attention to it, that can save you some big headaches down the road. Many vehicles have a temperature gauge on the dash that takes the temperature of the engi... More

In a Fog (Fogged Windows in Cold Weather)

May 5, 2024

It's bad enough in cold weather when ice and snow block your visibility. Add to that fog on the inside of your windows and you could be driving blind. So here are a few tips on how to keep your windows from fogging up when there's a chill in the air. You probably know fog is really condensation... More

The Light Nobody Wants to See (Check Engine Light)

April 28, 2024

You've probably had your Check Engine Light go on. Then it goes off and you figure, hey, whatever the problem was, it's gone now and I don't have to worry about it. Well, the problem may have gone away and it may not have. Your vehicle likely has one of these warning lights on the instrument pa... More